Open Pit Draining Pump Mine Dewatering Pump Open Pit Dewatering Pump

Home > PRODUCTS >

Open Pit Draining Pump Mine Dewatering Pump Open Pit Dewatering Pump

Open Pit Draining Pump Mine Dewatering Pump Open Pit Dewatering Pump

Open Pit Draining Pump Mine Dewatering Pump Open Pit Dewatering Pump
  • Technology Data Sheet Mine Dewatering - Groundwater Eng

    Technology Data Sheet Mine Dewatering ... In-pit pumping is normally carried out by robust pumps capable of pumping dirty water. Pump sets may be ... or drainage tunnels and adits driven near the open pit to promote drainage in fissured rocks of low hydraulic conductivity.

  • Open-Pit Dewatering: How It Works, and What Pump to Use ...

    Getting It Out, and Keeping It out.Submersible Slurry PumpsDry-Priming Trash PumpsWhere Does This Water Go?General rule of thumb: The deeper the pit, the more water you’ll encounter. You need to get it out, and keep it out.There are two steps. Both need solutions, and these solutions are mutually exclusive. The water in the open pit has to be removed, but it’ll return unless you also lower the groundwater level. A wellpoint dewatering system around the perimeter of your construction site will take care of lowering the groundwater level.With that solution underway, it’s time to focus on dewatering...
  • Some Technical Aspects of Open Pit Mine Dewatering

    Drainage Control for Surface Mines 22 Some Technical Aspects of Open Pit Mine Dewatering by V. Straskraba, Senior Mining Hydrogeologist, Dames Moore, Denver, Colorado, USA In recent years the increase in development of new open pit mines, especially in the Western U.S., is evident.

  • Drainage Control and Mine Dewatering at Faro Open Pit Mine

    Drainage Control and Mine Dewatering at Faro Open Pit Mine ... control and mine dewatering since mining started at the Faro open pit mine. Drainage and dewatering programs have been mainly implemented in three areas of the mine: the ... Valley, and the bottom of the open pit. These programs utilize a system of ditches, pipelines, sumps, pumps ...

  • Blog Mine Dewatering - Groundwater Eng

    In-pit pumping is normally carried out by robust pumps capable of pumping dirty water. Pump sets may be of the electric submersible type or of the self-priming surface pump type. ... more specialist dewatering methods are used in open pit mines. ... or drainage tunnels and adits driven near the open pit to promote drainage in fissured rocks of ...

  • Diesel Pioneer dewatering pump in Open Pit Mine All Pumps

    1500L Diesel Pioneer Dewatering Pump installed at Open Pit Mine. Case Studies; Mining; ... This method involves using dewatering pumps and tends to be more favourable. Dewatering by pumping ... We provided a Pioneer diesel dewatering pump PPSK66S14L2 to an open pit mine here in Australia.

  • Open Pit Mine Dewatering End Suction Water Pump

    Open Pit Mine Dewatering End Suction Water Pump IH series pump is single-stage , single-suction centrifugal pump , designed as per the interational standard ISO2858 . It is a replacement of type BA water pump which is applicable to industrial and urban water supply and discharge as well as the agriculture irrigation .

  • Xylem Mining Open Pit Dewatering - Xylem Mining

    Open Pit Dewatering Challenge : Water removal from mine shafts, open pits and active dewatering around mines Solution : Reliable and efficient dewatering solutions across the mine dewatering

  • Mine dewatering techniques - SlideShare

    Open Pit Groundwater Control A range of groundwater control techniques can be used, depending on the geology and the type of mine: • In-pit pumping – used to pump from sump areas within the pit • Perimeter dewatering wells – used to intercept lateral groundwater flow into the pit and to lower groundwater levels in advance of mining ...

  • Open pit drainage Grundfos

    The grey water in open pit mines typically contains abrasives such as stones, clay, sulphur, and the pH value can be very low. Grundfos dewatering pumps are designed to work in the toughest environments and can be found in mining applications and offshore industries worldwide.

  • Mine Dewatering

    operational cost for open pit mining operations. Dewatering an open pit mine is an important process and its ... the types of mine dewatering pumps you may require to successfully com-plete the job are ... dewatering system that would pump at three separate locations throughout

  • Open Pit and Mine Dewatering Pumps - Global Pumps

    The Purpose and Operation of Open Pit and Underground Mine Dewatering Pumps. At mining operations, quarries or gravel pits, underground dewatering and drainage is a requirement to ensure that mining operations continue unhindered, and provide an environment conducive to providing optimal production due to the high costs associated with operations such as undergound mining.

  • Mine Pit Dewatering - National Pump Energy (NPE)

    NPE were approached by the client as their previous pump supplier was unable to provide a reliable and efficient mine pit dewatering solution. NPE supplied 4 dewatering pumps and within 7 days the Pit floor was dry and our client experienced a 35-40% increase in their dewatering rates, so much so that 2 units are now on standby.

  • Optimizing Dewatering Processes in Mining Operations

    and sub-surface mining operations. Mine dewatering is an essential part of resource extraction, as it lowers the ... —In open-pit mines, a water table that is too high can destabilize mine walls, haulage roads, and ... and by installing pumps in special sumps on the mine floor to remove surface water. Mine dewatering opera-

  • Dewatering for open pit mines and quarries - SlideShare

    Aug 03, 2015  This presentation reviews the dewatering and groundwater control measures that can be used for open pit mines and surface quarries. ... Dewatering for open pit mines and quarries ... Angus Flexible Pipelines Highwall dewatering pump Flexible rising main for borehole pumps 27. preene TECHNOLOGY TRANSFER HDD (Horizontal Directional ...

  • Mine Dewatering Gardner Denver Pumps

    Dewatering is an important part of any open pit or underground mining operation. While it can be a complex and costly process, it is instrumental. If not planned for and managed properly, mine flooding or slope failures can cause major setbacks and threaten the safety of workers.

  • Open Pit Dewatering Pump Piping Fundamentals - KASA

    Open Pit Dewatering – Pump Piping Fundamentals Introduction Open pit dewatering typically encompasses a combination of diesel and/or electric driven pump-sets located “in-pit”, and, in some cases, located in groundwater bores either “in-pit” or “ex-pit

  • Open Pit Dewatering - KASA_Redberg

    "Open Pit Dewatering - Pumping Piping" is a two day pump training course which has been specifically designed for site-based dewatering teams, design engineers and hydrogeologists who are tasked with operating, maintaining, trouble-shooting or designing open pit (mine) dewatering systems.

  • Open Pit Dewatering Methods Xylem US

    Learn more about Xylem's open pit mine dewatering methods. Xylem offers a range of high performance open pit dewatering pumps to assist with open mining processes. ... and system decreasing down-time. Xylem offers a wide range of pump technologies, from submersible to dry mount, ensuring the right pump for every job. Rental options are also ...

  • Mine Pit Dewatering by NPE - YouTube

    Jun 18, 2017  NPE pump crews setting up a pontoon mounted pump and poly pipeline at a gold mine in Western Australia ... Mine Pit Dewatering by NPE National Pump Energy ... Clearing the neighborhood drain ...

  • Horizontal Drains – Their Use in Open Pit Mine Dewatering

    Drainage Control for Surface Mines 11 Horizontal Drains-Their Use in Open Pit Mine Dewatering INTRODUCTION by Ben L. Seegmiller, Principal, ... HORIZONTAL DRAINS-THEIR USE IN DEWATERING 259 . f Figure 1. Horizontal Drain Emplacement. 260 DRAINAGE CONTROL FOR SURFACE MINES .

  • Underground dewatering Grundfos

    Underground dewatering and drainage is necessary to ensure that mining operations continue unhindered. Grundfos dewatering pumps are designed to work in the toughest environments and can be found in mining applications and offshore industries worldwide.

  • Dewatering: a vital part of mining? - Weir Minerals

    Mar 21, 2017  Dewatering is a vital part of mining and the need to provide individual solutions to meet the unique operating characteristics of mines is greater. ... Dewatering: a vital part of mining? - Weir Minerals . ... While drawing water from open pit and underground mines is crucial, and the task that most people think about when the subject of ...

  • Open Pit Mining Process Challenges Xylem US

    Groundwater control and dewatering is a vital part of nearly any open pit and underground mine because it helps: Stabilize the mine pit walls during and after excavation Improve safety at the mine

  • Mine Pit Dewatering by NPE - YouTube

    Jun 18, 2017  NPE pump crews setting up a pontoon mounted pump and poly pipeline at a gold mine in Western Australia ... Mine Pit Dewatering by NPE National Pump Energy ... Clearing the neighborhood drain ...

  • Dewatering: a vital part of mining? - Weir Minerals

    Mar 21, 2017  Dewatering is a vital part of mining and the need to provide individual solutions to meet the unique operating characteristics of mines is greater. ... Dewatering: a vital part of mining? - Weir Minerals . ... While drawing water from open pit and underground mines is crucial, and the task that most people think about when the subject of ...

  • Open-pit Drainage Grundfos

    The grey water in open-pit mines typically contains abrasives such as stones, clay, sulphur, and the pH value can be very low. Grundfos dewatering pumps are designed to work in the toughest environments and can be found in mining applications and offshore industries worldwide.

  • Review on Dewatering Pumping Network for Underground

    Keywords— Underground mine, dewatering, and pumping network ... pumped, utilizing down-the-hole pumps, drilled into open pit walls to drain aquifers under hydrostatic pressure, or ... mouth of the pit and thus drain the mine with constant pumping. In about 130 B.C. Hero designed a pumping

  • Mine dewatering, Pit dewatering pumps, Mono Pump Spare ...

    Challenge Pumps are specialists in the field of underground and open pit mine dewatering. ... pump parts. Challenge Pumps maintain a fast and efficient off site facility where they can rebuild pumps at a fraction of the replacement cost by reusing or reclaiming pump parts and putting them back into service. Trust WEARTUFF™ Pumps. WEARTUFF ...

  • Sykes Pumps, the solution for mine dewatering in Africa

    T wo Sykes XH150 trailer mounted pumps will soon be doing dewatering duty at a mine in Africa, supplied by southern African distributors Integrated Pump Rental based in Jet Park, Gauteng.. This range of diesel powered units is ideal for dewatering an open pit, offering characteristics that include high head and head flow, according to Lee Vine, managing director of Integrated Pump Rental.

  • Underground dewatering Grundfos

    Underground dewatering and drainage is necessary to ensure that mining operations continue unhindered. Grundfos dewatering pumps are designed to work in the toughest environments and can be found in mining applications and offshore industries worldwide.

  • Open Pit Mine Dewatering End Suction Water Pump

    Oct 31, 2017  Open Pit Mine Dewatering End Suction Water Pump IH series pump is single-stage , single-suction centrifugal pump , designed as per the interational standard ISO2858 . It is a replacement of type BA water pump which is applicable to industrial and urban water supply and discharge as well as the agriculture irrigation .

  • Open Pit Mining Process Challenges Xylem US

    Groundwater control and dewatering is a vital part of nearly any open pit and underground mine because it helps: Stabilize the mine pit walls during and after excavation Improve safety at the mine

  • Mine dewatering: technology + fit-for-purpose solutions ...

    Jul 18, 2018  Variations in weather conditions can have a significant effect on open-pit mining in particular, and even mines operating above the water table can be subject to significant influxes of water caused by environmental changes such as heavy rainfall. ... submersibles and multistage pumps to ... a slurry pump is best suited to a dewatering ...

  • Dewatering for the Mining Industry: a Case Study - Pump ...

    Dewatering for the Mining Industry: a Case Study. ... It became an open pit development site in 2007-2008. Currently, it has a capacity of 5.5 million TPA (tonnes per annum) of ore. Production is currently at 800,000 dry metric TPA. ... The mine dewatering pumps needed a flow rate of 180 l/s and a static head of 385 m. The materials had to be ...

  • China Open Pit Mine Dewatering Close Coupled Monoblock ...

    Open Pit Mine Dewatering End Suction Water Pump QI series pump is single-stage , single-suction centrifugal pump , designed as per the interational standard ISO2858 . It is a replacement of type BA water pump which is applicable to industrial and urban water supply and discharge as well as the agriculture irrigation .

  • Comparison of Designs for the Dewatering of Coal, Gold

    Summary of methods of mine dewatering . Coal Mine Drainage . Figure 2, shows the distribution of coal fields in Southern Africa. ... For open pit mines, the main concern is accurate storm water control. This is further divided into control of clean and ... Mine dewatering is done through the use of sump pumps located in the lowest point of the ...

  • Dewatering Mines - pumpsandsystems

    Feb 28, 2019  Mine dewatering pumps generally need to pump water horizontally-from a smaller sump to a larger sump-or vertically from the bottom of the pit up to the elevation of the mine, and then horizontally to a discharge point.

  • Underground dewatering Grundfos

    Underground dewatering and drainage is necessary to ensure that mining operations continue unhindered. Grundfos dewatering pumps are designed to work in the toughest environments and can be found in mining applications and offshore industries worldwide.

  • Open Pit Mine Dewatering End Suction Water Pump

    Oct 31, 2017  Open Pit Mine Dewatering End Suction Water Pump IH series pump is single-stage , single-suction centrifugal pump , designed as per the interational standard ISO2858 . It is a replacement of type BA water pump which is applicable to industrial and urban water supply and discharge as well as the agriculture irrigation .

  • Dewatering for the Mining Industry: a Case Study - Pump ...

    Dewatering for the Mining Industry: a Case Study. ... It became an open pit development site in 2007-2008. Currently, it has a capacity of 5.5 million TPA (tonnes per annum) of ore. Production is currently at 800,000 dry metric TPA. ... The mine dewatering pumps needed a flow rate of 180 l/s and a static head of 385 m. The materials had to be ...

  • China Open Pit Mine Dewatering Close Coupled Monoblock ...

    Open Pit Mine Dewatering End Suction Water Pump QI series pump is single-stage , single-suction centrifugal pump , designed as per the interational standard ISO2858 . It is a replacement of type BA water pump which is applicable to industrial and urban water supply and discharge as well as the agriculture irrigation .

  • Griffin Dewatering - Mining Technology Mining News and ...

    Griffin’s pumps provide the highest air-handling capacity on standard units in the market and are uniquely designed to address the needs encountered in dewatering, bypass, and open pumping and hydraulic-submersible pump applications.

  • Dewatering solutions for mining applications - Making Waves

    Dewatering solutions for mining applications. ... 3 Open-pit drainage. Why: Surface water and groundwater that enter the pit have to be removed continuously in order to maintain production. ... Why: Face and stage dewatering pumps remove ground and production water. Because the front of a drift moves forward as the mining continues, there is no ...

  • Open-pit Drainage Grundfos

    The grey water in open-pit mines typically contains abrasives such as stones, clay, sulphur, and the pH value can be very low. Grundfos dewatering pumps are designed to work in the toughest environments and can be found in mining applications and offshore industries worldwide.

  • Dewatering solution for open mine pit - technosub.net

    Mineflex mining applications-Hose Solutions; Dewatering solution for open mine pit SKYFlow "dewatering solution for open pit mines" It is an economical and easy to deploy in open pit solution. The SKYFlow can jump over walls up to 120 meters. This is a great alternative and a serious option in terms of simplicity and speed of installation.

  • Mine dewatering: technology + fit-for-purpose solutions ...

    Jul 18, 2018  Variations in weather conditions can have a significant effect on open-pit mining in particular, and even mines operating above the water table can be subject to significant influxes of water caused by environmental changes such as heavy rainfall. ... submersibles and multistage pumps to ... a slurry pump is best suited to a dewatering ...

  • Dewatering Mines - pumpsandsystems

    Feb 28, 2019  Mine dewatering pumps generally need to pump water horizontally-from a smaller sump to a larger sump-or vertically from the bottom of the pit up to the elevation of the mine, and then horizontally to a discharge point.

  • Dewatering: A Vital Part of Minerals Mining MINING

    Oct 23, 2017  Dewatering: A Vital Part of Minerals Mining. ... the amount of water entering a mine, especially at open pit sites. ... operated pump stations and locally-manufactured pumps which proved to

  • How to Estimate the Cost of a Temporary Site Dewatering

    How to Estimate the Cost of a Temporary Site Dewatering System Table of Contents ... header pipe, which is then connected to one or more pumps. The vacuum effect created by the ... system’s pump will draw water from the wellpoints thereby lowering the level of the groundwater

  • Mine dewatering - Wikipedia

    In the 20th century submersible pumps offered another innovation in mine dewatering. In the current days the dewatering techniques and systems are so advanced and well defined for each type of mine - open pit or underground - that even mines with thousands of meters deep can be

  • Comparison of the dewatering of underground and open pit ...

    The purpose of a dewatering system for underground and open pit coal mine is to control ground water levels and to reduce pore water pressure in the ground so dewatering systems are also important...